ADP LWN EFI Live Tuning (2016-2021 2.8L Duramax)

ADP LWN EFI Live Tuning (2016-2021 2.8L Duramax)

SKU: ADP-LWN-EFI

Benefits of Tuning

  • Makes 225+ RWHP and 415+ ft-lbs of torque
  • With our tuning you will never see black clouds of smoke during acceleration
  • Improved fuel economy by optimizing shift patterns and converter lock up
  • No diesel smells while idleing or during cold start conditions
  • No uncomfortable droning or resonance during towing
  • Easily return to stock with factory restore file
  • Does not make you a target for Law Enforcement
  • Tune Power Levels

    Tune Horsepower Torque Gains
    Stock 147 rwhp 295 ft-lbs Stock
    Optimized 162 rwhp 339 ft-lbs +15 rwhp / 44 ft-lbs
    Light Tow 181 rwhp 358 ft-lbs +34 rwhp / 63 ft-lbs
    Street 207 rwhp 375 ft-lbs +60 rwhp / 80 ft-lbs
    Race 225 rwhp 415 ft-lbs +78 rwhp / 120 ft-lbs

     

    With our 2018 Chevrolet Colorado ZR2 2.8L Duramax being rated at 181hp/369 ft-lbs at the engine our baseline dyno numbers showed a drivetrain loss of about 19% which is expected of a vehicle with large tires. With the calculated power loss through the drivetrain, engine power numbers are as follows.

    Stock - 175 hp /  351 ft-lbs

    Optimized - 193 hp / 403 ft-lbs    (+18 hp / 52 ft-lbs)

    Light Tow - 215 hp / 426 ft-lbs    (+40 hp / 75 ft-lbs)

    Street - 246 hp / 446 ft-lbs    (+71 hp / 95 ft-lbs)
    Torque Protection Removed/Turbo Overspeed Allowed

    Race - 268 hp / 494 ft-lbs   (+93 hp / 143 ft-lbs)
    Torque Protection Removed/Turbo Overspeed Allowed

  • Description

    ADP EFI Live Tuning is designed to take what the manufacturer left on the table with modest tuning and give that back to you in the form of increased fuel efficiency, power, and driveability. This tuning is designed to put a smile on your face, not break the bank, and give you increased capability whether your truck is a daily driver, tow pig or weekend hauler.


    Testing and Validation

    During our development and testing of ECM and TCM Calibrations for the 2.8L Duramax Canyon/Colorado we traversed many climates. Testing included driving at 6412ft above sea level in Manitou Springs, CO all the way down to 331ft above sea level in Daleville, AL. During the course of our testing we drove unloaded on road and off-road experiencing temperatures from 102F down to -17F. During our towing test we loaded the vehicle with 800lbs of cargo and connected a 5500lb trailer and began a cross country drive. 1200 miles in total one way for our initial tow test. We also took our vehicle to a state certified emissions testing center for a dyno based test. During testing the vehicle produced 02% Opacity or better at Zero Shift, 40mph, 50mph, and 60mph testing. Emissions controls received a Pass status in Electronic Engine Controls, Catalytic Converter, PCV System and EGR System. Overall results were green across the board with passing results in the state of Colorado on 12 Septemeber 2019. 

    *ADP Tuning will only support vehicles with factory emissions*

    Included Features

    o Enhanced drivability throughout the RPM range- More consistent power delivery under all conditions.

    o Dead Pedal removed- Adjusted to help you get moving from a start quicker and safer, reduced throttle delay compared to stock calibration.

    o Improved quick warm up mode- Bring engine temps up to normal operating range quicker for enhanced engine lubrication and quicker heat production for occupants.

    o All OEM safeties left intact- Rest assured knowing ALL factory engine protection measures have been left in operation.

     

    Special Features (By Request)

    o Calibrate Speedometer for tire size/gear changes

    o Adjust rev limiter

    o Increase max speed for emergency vehicles (subject to tire speed rating)

    o Reduce max speed for fleet vehicles


    *DSP4 Tuning not available for 2019/2020 Trucks*

  • Install Info

  • What is EFI Live?

    EFI Live Tuning is an all in one system that allows scanning, datalogging, reading and flashing of stock or custom calibrations to your factory engine and transmission controllers. 

    Tuning: Let us know what you need! Whether it's for a daily driver and weekend track truck that you want more power in or a stock tow rig that you just want the best mileage from. All our tuning is custom written for your truck and how you use it. Just let us know in the order notes and we'll get them written for you.

    SOTF/DSP/CSP: Allows you to switch your tunes on-the-go with a 4 or 5 stage rotary knob that is to be mounted on your dash for quick adjustments between tunes.

    Controller Auth Code (GM 1.6L/2.8L): If you are tuning your vehicle for the first time, you will need this unlock code to allow reading/writing access for your engine controller in your 17+ Vehicles. The steps and procurement of the code can be found here. Controller Auth Code

    This product will include American Diesel Power tuning with either a single tune or switchable tunes. American Diesel Power writes their custom tunes for the Cummins/Duramax/Ecotec. These calibrations will allow you to make safe and reliable power in your Cummins, Duramax, or Ecotec Diesel powered vehicle.

$300.00Price
Tune Type
Include Autocal
Include DSP4 Switch
Trans Tuning

Follow us 

  • Facebook
  • YouTube
  • Instagram

© 2018-2020 by American Diesel Power

MILITARY DISCOUNT

DISCOUNT FOR ACTIVE DUTY, RESERVE, NATIONAL GUARD AND VETERANS
(Current Orders or DD214 to qualify)